Latest Re-Flash

[altaski]

Has anyone heard of this latest flash and when it was released? And maybe what it does?

Part No. L33P-18881-T, File Name SW-L33PET000

 

[offset_98]

what's it do? I was just at the dealer 3 weeks ago and they didn't reflash me that time. Usually if there is a reflash, they'll do it when the car is there for an oil change.

 

[altaski]

Latest Re flash

I had been asking the dealer for the last 3 months to see about a flash update that would fix my overheating issue. It's because things pointed to too high Exhaust gas Temp, why, ?, but timing seemed to far advanced, fuel seemed to lean, shift pattern was different than before as it stayed in high gears to much.
So I asked dealer to re flash just because and I would pay for it, and guess what.....they found there WAS a newer update!(hand)

Took that act to get them to LOOK for a updated flash.

 

[altaski]

Latest Re Flash

So nobody knows anything about this flash? It's newer than 2/08 and its now in my car. Do you have yours?

 

[erhayes]

Give us the TSB number for the reflash.

 

[altaski]

Latest Re Flash

I did, in the first post. These are the only numbers the Dealer has as it is NOT a tsb reflash.

Part No. L33P-18881-T, File Name SW-L33PET000

So take it from there.

 

[offset_98]

SW-L33PET000 = http://www.accessecu.com/accessport/mazda/AP-MAZ-02/TSB 01-02208 CDFP.pdf

 

[erhayes]

Thank you offset 98

 

[altaski]

Thank you offset 98

Thank you,

I Now know the fix to my overheat problem.

Cause-Lean condition due to fuel pump/flash (to change voltage), caused high EGT's, made turbo get excessively hot, heat soak to block caused overheating.

Hope-this excessive overheating of turbo hasn't damaged it! I do everything I can to make it last the longest possible-change oil, use synthetic, and have a turbo timer. Would really hate to see all that preventive maintenance be for not!

Last month I was talking to a shop that did custom performance flash's for Mazda's. After describing my problem and asking if he could help, he said it sounds more like a lean condition caused by fuel pump pressure to low! He must have known of this bulletin. It's truly amazing the Mazda dealers(s) can't be intuitive enough to bother checking or even lift a finger to try and fix an obvious heat problem. And the fix has been there since April 08!

 

[TRXSandRacer02]

YEAR VEHICLE NAME SUBJECT OF REPAIR RI/SB
NEW PCM/TCM P/N & FILENAME information
________________________________________________________________________
07-08 Mazdaspeed 3 Rough Idle, Lack of Power
06-07 Mazdaspeed 6 and/or MIL on P2177//P2187 5701/01-022/08
07-08 CX-7
PCM
B52.2
Model Spec Eng. Trans Filename New PCM Calibration P/N
------------------------------------------------------------------------
Mazdaspeed 3 Cal SW-L39RED000 L39E-18-881D
Mazdaspeed 3 Fed/Can SW-L39SED000 L39S-18-881D

Mazdaspeed 6 Cal SW-L38JEG000 L38J-18-881G
Mazdaspeed 6 Fed/Can SW-L38KEG000 L38K-18-881G
07 CX-7 2WD Cal SW-L33LET000 L33L-18-881T
07 CX-7 2WD Cal SW-LKYXEB000 LKYX-18-881B
07 CX-7 4WD Cal SW-L33MET000 L33M-18-881T
07 CX-7 4WD Cal SW-LKYZEB000 L3YK-18-881B
07 CX-7 2WD Fed/Can SW-L33NET000 L33N-18-881T
07 CX-7 2WD Fed/Can SW-LKZ1EB000 LKZ1-18-881B
07 CX-7 4WD Fed/Can SW-L33PET000 L33P-18-881T
07 CX-7 4WD Fed/Can SW-LKZ2EB000 LKZ2-18-881B
07 CX-7 2WD Mex SW-L39JEF000 L39J-18-881F
07 CX-7 4WD Mex SW-L39KEF000 L39K-18-881F
08 CX-7 2WD Cal SW-L39LED000 L39L-18-881D
08 CX-7 4WD Cal SW-L39MED000 L39M-18-881D
08 CX-7 2WD Fed/Can SW-L39NED000 L39N-18-881D
08 CX-7 4WD Fed/Can SW-L39PED000 L39P-18-881D

NOTE: For those vehicles built before April 7, 2007, replace the fuel pump with a updated pump. If the pump was built after March 26, 2007, the pump should not be replaced. Please refer to Parts Information below.

New Old Part name Qty
L3K9-13-35ZC L3K9-13-35ZB Fuel Pump 1
Note: The old part number (35ZB) may be used if it was produced after April 7, 2007.

High Pressure fuel pump identification information:
The production date of the high-pressure fuel pump is laser etched onto the pipe that the high-pressure fuel pipe threads onto.

The production date is marked as a 4 digit code "YMDD on the pipe.
Y for Year: 7 for 2007
M for month: 9 for September, X for October, Y for November,
Z for December
DD for Date: 07 for the 7th day of the month.

Example: "4Z16" means December 16,2004.
"7608" means June 8, 2007.

 

[altaski]

Fuel Pump tsb

I got the new fuel pump installed and the reflash per the tsb.

Under normal (non towing) driving, the car runs one whole mark lower on the temp gauge. So, less lean condition, lower exhaust gas temp, equals lower operating temp.

We shall see under towing at later date.

(cool)

 

[altaski]

Oh, and the date on the old fuel pump was May 2006, and the new one is July 2008!

 

[erhayes]

What was the listed pump replacement cost even though it was under warranty?

 

[altaski]

Fuel pump

Cost $457

 

[erhayes]

Thanks. My pump is being replaced tomorrow. Darn-pump back ordered

 

[ZOOMit]

What is this number? Purchased a CX-7 last Dec and noticed this on the door jamb

L33N-18881-T
2007 CX-7